So, I just dropped off my car this morning to have the clutch replaced. I just replaced the clutch about 6 months ago because it was slipping. This is what controls your clutch! You will find a vast difference in the prices from a dealer service department to an inde shop. I drive my car well and cannot understand why this has to be replaced. I did some investigating on line and it appears that Hyundai has a major problem with the clutch they install on these cars. The problem could also be in the clutch itself, one of the damper springs or diaphragm fingers on the pressure plate could be loose or broken causing the clutch not to release properly.
Look for slave cylinder restrictor on this site. During cold weather emergency brake sticks took it in and they couldnt find anything wrong, go figure. Find out more about our. Through online research, he found numerous complaints for the same failure as his year, make, and model vehicle. A manual transmission vehicle used in the city will require clutch service more frequently than one driven mostly on the highway.
I nearly got t-boned by a truck during normal traffic because my clutch disengaged and I started slowing down. I would strongly recommend not only taking careful precaution not to disturb the orientation of the gears in this process, but also to replace the timing belt and water pump at the same time. And more importantly, far more reliable. And a written estimate of cost from dealer before we proceed. You have to remove the timing belt tensioner, and then you can remove the bolts for the water pump. The dealer has quoted me 1700 dollars and are saying that it is not covered under warranty because it is wear and tear. Weeks later I had taken my car to the local dealership I purchased the car from to get the oil changed, and a routine inspection.
If not, can you try to explain it really good for me? The problem is solvable early on, but if the car has the delay valve and spring left in for too long, the clutch becomes irreparably damaged due to the massive slipping. On October 15, 2007, at 37,500 miles, there began a similar clutch pedal problem, later the rpms of the engine were increasing, however the gears were not engaging fully, another clutch failure in less than six months. The contact was informed that if he took the vehicle to a third party, it would not be recognized by the dealer. The dealer tried to say that it was not covered under warranty but they ended up covering the replacement after much discussion. A week later I brought my car back and they said they wanted to replace the entire transmission, under warranty. I have driven hundreds of thousands of manual shift miles in several cars and never had a clutch failure.
The problem could be hydraulic, like air in the system or the slave or master not functioning properly. Blaming it on how the car is driven is both a shameful business practice and crime against consumers everywhere. The truck stopped to help and I got my car home afterwards. The current and failure mileages were 37,000. When installing Hyundai Tiburon clutch kit, we recommend replacing or resurfacing your Hyundai Tiburon flywheel. I was reading on newtiburon. We also recommend changing your Hyundai Tiburon clutch master cylinder and Hyundai Tiburon slave cylinder when doing a clutch job.
I am looking into alternative solutions--including trading my car in--as I am not confident the defects will be corrected. There is no reason why this should have occurred but I have had no problems since then. I have a 5 speed. I want to know what can be done about this. During the replacement process the clutch and flywheel was found to have 'hotspots' on it and was recommended to be replaced. Please remember to rate my answer.
However, we see that there are hundreds of complaints on this clutch system and a class action lawsuit has been filed against Hyundai in orange county superior court, case 06cc00052. I have one that has done them from Audis up to Ford diesel trucks. I find it very odd that the dealer refuses to give me the part numbers, relying on quick hand written quotes… what do you think? You don't want to go through this process all over again do you? Are you in need of a new Hyundai Tiburon clutch? In order for the dealership to uphold the warranty, you have to have the vehicle maintenance done at a Hyundai dealership and at the specified mileage. Then you came to the right place where you can purchase the best quality Hyundai Tiburon clutch kit at below wholesale price. Hyundai Tiburon clutch kit comes with pressure plate, clutch disc, throwout bearing, pilot bearing if required , and alignment tool. The grabbing point on the clutch is when its almost all the way out about 1 inch from the top and I've just recently noticed that I barely have to push the clutch in to change gears about half way or less.
If the car were mine I would use the aftermarket clutch assembly and not worry one moment about it. While at a traffic light I experienced complete clutch failure, the car would not go in to gear. I gave them the okay to do this. After leaving the vehicle at the dealer for two days, he was informed that the rpm's had been replaced and that there was an issue with the clutch in the vehicle. Thank you for correcting me.
In reading other complaints, this seems to be an on going problem with the standard transmissions in the Hyundai's. I have to disagree with Stoveguy that a clutch do not wear out in 110,000 miles. . I have driven cars with manual transmissions for 20 years. Upon purchasing the vehicle, the clutch would stick intermittently. The clutch and related parts to my old '89 Accord outlasted the body, driven ti 585,000 miles before retirement. Car makers sub out the majority of parts they use including clutch assemblies.
There should be something done about this. I was just wondering if my car has the bad part and should be replaced. The contact was eventually able to free the clutch and continue driving. Their house brand of Chicken soup is made by campbells. After doing some research, I have found that there is not only a class action lawsuit against the Hyundai corporation for a defective clutch in the 2003 Hyundai Tiburon. I can't find any information on why this is happening. It's always had a high grabbing point, even the day the clutch had been replaced! Seats wont latch sometimes after letting someone out from the back.